| |
23-1 Electrical (table of
contents)
23-2
Special tools required
23-3
Troubleshooting Precautions
23-3
Five-Step troubleshooting
23-4
Schematic Symbols used in this section
23-5
Relays and Control unit locations - engine compartment (photo)
23-6
Relays and Control unit locations - dashboard and floor (photo)
23-7
23-8
Connector and Wire Harness Routing (with plug numbers and locations)
23-9
23-10
Engine Wiring Harness - STD/DX models
23-11 (photo)
23-12
Engine Wiring Harness - Si/HF models
23-13 (photo)
23-14
Main Wiring Harness (all models)
23-15 (photo), 23-16
(dash) , 23-17 (photo - dash)
23-18 A/C
Wiring Harness and Fuel Tank Wiring
23-19 (photo)
23-20
Rear Wire Harness
23-21 (photo)
23-22
Hatch and License Plate Wires (photo)
23-23
Drivers/Passenger Door wires (photo)
23-24
Dashboard Wire Harness (photo)
23-25
Roof, Defogger, Belt Wire Harness (photo)
23-26
Main Fuse Box - engine bay (photo)
23-27
Dash Fuse Box (photo)
23-28
Circuit Identification - power distribution
23-29, 23-30
(USA), 23-31 (Canada)
23-32
Ground Identification
23-33, 23-24
23-35
Battery Testing
23-36
Ignition Switch (Test and Replacement)
23-37
Lock Cylinder Replacement (Manual Transmission Only)
23-37
Steering Lock Replacement
23-38
Starting System component location index
23-39
Starter Interlock System (Manual Transmission Only)
23-40
Starting System Circuit Diagram
23-41
Starter Test
23-42
23-43
Starter Relay Test (Manual Transmission Only)
23-43
Clutch Interlock Switch (Manual Transmission Only)
23-44
Starter Solenoid Test
23-45
23-45
Starter Replacement
23-46
Starter Overhaul (ND Type) - exploded diagram
23-47
Starter Overhaul (Mitsuba Type) - exploded diagram
23-48
Starter Overhaul (both types)
23-49, 23-50,
23-51, 23-52,
23-53, 23-54
23-55
Ignition System Component Location Index (photo)
23-56
Ignition System Description (how the car starts)
23-57
Ignition System Circuit Diagram
23-58 Ignition
Timing Inspection and Setting (setting the timing)
23-59
Distributor Top End Inspection
23-59
Distributor Removal
23-60
Distributor Installation (location of 1-2-3-4 sparkplug wires locations on cap)
23-61
Distributor Exploded diagram
23-62
Distributor Reassembly
23-63 Igniter
Unit Input Test
23-64
Ignition Coil Test
23-65
Ignition Coil Replacement
23-66
Spark Plug Inspection (including gap and plug recommendations)
23-67
Charging Component Location Index (photo)
23-68
Charging System Description (how the ECU charges the system)
23-69
Charging System Circuit Diagram
23-70
Charge Warning Light Test
23-71 ELD
(Electrical Load Detector) Test (USA)
23-72
Alternator and Regulator Test
23-73
23-74
Alternator Replacement
23-75
Alternator Overhaul (Nippon Denso type) - exploded diagram
23-76
Alternator Overhaul (Mitsubishi type) - exploded diagram
23-77
Rectifier Removal (Mitsubishi type)
23-78
Rectifier Testing (both types)
23-79
Alternator Brush Inspection
23-80
Alternator Rotor Slip Ring Test
23-80
Stator Test
23-81
Alternator Reassembly
23-81
Alternator Belt Adjustment
23-82
Cooling Fan System Component Location Index
23-83
Cooling Fan System Circuit Diagram (USA)
23-84
Cooling Fan System Circuit Diagram (Canada)
23-85 Fan
Motor Test
23-85
Coolant Temperature Switch Test
23-86
Cooling Fan Relay Test
23-87 Gauge
Assembly Location Index
23-88
Gauge Assembly Circuit Diagram
23-89
23-90
Gauge Assembly
23-91
Bulb Locations (with tachometer)
23-92
Gauge Assembly (Removal)
23-92
Speed Pulser Test (VSS)
23-93
Gauge Disassembly
23-94
Coolant Temperature Gauge Test
23-94
Coolant Temperature Sender Test
23-95
Fuel Gauge Test
23-96
Fuel Gauge Sending Unit Test/Replacement
23-97
Interlock System Component Location Index
23-98
Interlock System Description
23-99
Interlock System Circuit Diagram
23-100
Interlock System Unit Input Test
23-101
Interlock System Key Interlock Solenoid Test
23-102
Interlock System Shift Lock Solenoid Test/Replacement
23-103
Shift Lever Position Indicator Component Location Index
23-104
Shift Lever Position Indicator Circuit Diagram
23-105
Shift Lever Position Indicator Input Test
23-106
Shift Lever Position Indicator Console Switch Test
23-107
23-108
Integrated Control Unit Circuit Diagram (USA)
23-109
Integrated Control Unit Circuit Diagram (Canada)
23-110
Integrated Control Unit Input Test
23-111, 23-112
23-113
Key-On Warning System (Replacement/Testing)
23-114
Oil Pressure Warning System (oil pressure switch)
23-114
Brake Warning System
23-115
Parking Brake Switch Test
23-115
Brake Fluid Level Switch Test
23-116
Lighting System Component Location Index
23-117
Lighting System Circuit Diagram (USA)
23-118
Lighting System Circuit Diagram (Canada)
23-119
Lighting System Turn Signal Switch Test
23-120
Lighting System Daytime Running Light (CANADA ONLY)
23-121
Lighting System Daytime Running Light Resistor Test (CANADA ONLY)
23-122
Lighting Switch Replacement
23-122
Headlight Adjustment
23-123
Headlight Replacement
23-123
Taillight Replacement
23-124
Dome Light Test
23-125
Door Switches Test
23-125
Trunk Light Test
23-126
Trunk Latch Switch (test/replacement)
23-127
Back-up Light (reverse) Circuit Diagram
23-128
Back-up Light (reverse) test
23-129
Back-up Light replacement
23-129
Brake Lights Circuit Diagram
23-130
Brake Lights Test
23-130
High Mount (third) brake light replacement
23-131
Side Marker/Turn Signal/Hazard Flasher System Component Location Index
23-132
Side Marker/Turn Signal/Hazard Flasher System Circuit Diagram (USA)
23-133
Side Marker/Turn Signal/Hazard Flasher System Circuit Diagram (Canada)
23-134
Side Marker/Turn Signal/Hazard Flasher System Relay Test
23-135
Hazard Switch Removal
23-135
hazard Switch Test
23-136
Dashlight Brightness Control Component Location Index
23-136
Dashlight Brightness Control Circuit Diagram
23-137
Brightness Controller Removal
23-137
Brightness Controller Test
23-138
Brightness Unit Input Test
23-139
Stereo Sound System Component Location Index
23-140
Stereo Sound System Circuit Diagram
23-141
Stereo Sound System Unit Removal
23-141
Stereo Sound System Wiring Diagram (for plug)
23-142
Stereo Sound System Speaker Replacement
23-142
Clock Removal
23-143
Clock Terminal Locations
23-143
Cigarette Lighter Replacement (Si only)
23-144
23-144
Cigarette Lighter Relay Test
23-145
Horn Circuit Diagram
23-145
Horn Test
23-145
Horn Switch Test
23-146
Rear Window Defogger Component Location Index
23-147
Rear Window Defogger Circuit Diagram
23-148
Rear Window Defogger Troubleshooting Cross reference
23-149
Rear Window Defogger Test and Repair
23-150
Rear Window Defogger Switch Removal and Test
23-151
Rear Window Defogger Relay Test
23-152
Sunroof (Si Only) Component Location Index
23-153
Sunroof (Si Only) Circuit Diagram
23-154
Sunroof (Si Only) Electrical Troubleshooting
23-155
Sunroof (Si Only) Function Test
23-156
Sunroof (Si Only) Switch Test
23-156
Sunroof (Si Only) Tilt Up Switch
23-157
Sunroof (Si Only) Motor and Relay Test
23-158
Wipers/Washers Component Location Index
23-159
Wipers/Washers Circuit Diagram
23-160
Wipers/Washers Troubleshooting Diagram
23-161
Wipers/Washers Switch (stalk) Test
23-162
Wipers/Washers Switch Replacement
23-162
Windshield Wiper Motor Test
23-163
Windshield Wiper Motor Replacement
23-163
Rear Window Wiper Motor Test
23-164
Rear Window Wiper Motor Replacement
23-164
Washer Motor Test
23-165
Washer Replacement
23-166
Automatic Seat Belt Component Location Index
23-167
Automatic Seat Belt Description
23-168
Automatic Seat Belt Circuit Diagram
23-169
Automatic Seat Belt Trouble Shooting
23-170
Automatic Seat Belt Control Input Test
23-171
23-172
Seat Belt Switch Test
23-172
Door Latch Switch Test
23-173 Retractor
Solenoid/Solenoid Sensor Switch Test
23-174
Seat Belt Beeper/Reminder Light (removal and test)
23-175
23-175
Seat Belt Retractor Inspection
23-176
Wiring Diagrams Index
|